Misplaced Pages

#652347

47-535: Glenbawn Dam is a major ungated earth and rock fill with clay core embankment dam with concrete chute spillway plus fuse plugs across the Hunter River upstream of Aberdeen in the Hunter Valley of New South Wales , Australia. The dam's purpose includes flood mitigation , hydro-electric power , irrigation , water supply and conservation. The impounded reservoir is called Lake Glenbawn . Glenbawn Dam

94-575: A gel of orthosilicic acid ).) The clay minerals formed depend on the composition of the source rock and the climate. Acid weathering of feldspar -rich rock, such as granite , in warm climates tends to produce kaolin. Weathering of the same kind of rock under alkaline conditions produces illite . Smectite forms by weathering of igneous rock under alkaline conditions, while gibbsite forms by intense weathering of other clay minerals. There are two types of clay deposits: primary and secondary. Primary clays form as residual deposits in soil and remain at

141-836: A great capacity to take up water, and they increase greatly in volume when they do so. When dried, they shrink back to their original volume. This produces distinctive textures, such as mudcracks or "popcorn" texture, in clay deposits. Soils containing swelling clay minerals (such as bentonite ) pose a considerable challenge for civil engineering, because swelling clay can break foundations of buildings and ruin road beds. Clay minerals most commonly form by prolonged chemical weathering of silicate-bearing rocks. They can also form locally from hydrothermal activity. Chemical weathering takes place largely by acid hydrolysis due to low concentrations of carbonic acid , dissolved in rainwater or released by plant roots. The acid breaks bonds between aluminium and oxygen, releasing other metal ions and silica (as

188-402: A major challenge in civil engineering . The defining mechanical property of clay is its plasticity when wet and its ability to harden when dried or fired. Clays show a broad range of water content within which they are highly plastic, from a minimum water content (called the plastic limit ) where the clay is just moist enough to mould, to a maximum water content (called the liquid limit) where

235-598: A rock-fill dam is New Melones Dam in California or the Fierza Dam in Albania . A core that is growing in popularity is asphalt concrete . The majority of such dams are built with rock and/or gravel as the primary fill. Almost 100 dams of this design have now been built worldwide since the first such dam was completed in 1962. All asphalt-concrete core dams built so far have an excellent performance record. The type of asphalt used

282-551: A rock-fill dam. The frozen-core dam is a temporary earth dam occasionally used in high latitudes by circulating a coolant through pipes inside the dam to maintain a watertight region of permafrost within it. Tarbela Dam is a large dam on the Indus River in Pakistan , about 50 km (31 mi) northwest of Islamabad . Its height of 485 ft (148 m) above the river bed and 95 sq mi (250 km ) reservoir make it

329-411: A shape like a bank, or hill. Most have a central section or core composed of an impermeable material to stop water from seeping through the dam. The core can be of clay, concrete, or asphalt concrete . This type of dam is a good choice for sites with wide valleys. They can be built on hard rock or softer soils. For a rock-fill dam, rock-fill is blasted using explosives to break the rock. Additionally,

376-403: A shell of locally plentiful material with a watertight clay core. Modern zoned-earth embankments employ filter and drain zones to collect and remove seep water and preserve the integrity of the downstream shell zone. An outdated method of zoned earth dam construction used a hydraulic fill to produce a watertight core. Rolled-earth dams may also employ a watertight facing or core in the manner of

423-452: Is Armenian bole , which is used to soothe an upset stomach. Some animals such as parrots and pigs ingest clay for similar reasons. Kaolin clay and attapulgite have been used as anti-diarrheal medicines. Clay as the defining ingredient of loam is one of the oldest building materials on Earth , among other ancient, naturally occurring geologic materials such as stone and organic materials like wood. Between one-half and two-thirds of

470-495: Is 2,614 hectares (6,460 acres) and the catchment area is 1,300 square kilometres (500 sq mi). The ungated concrete chute spillway is capable of discharging 11,115 cubic metres per second (392,500 cu ft/s). An upgrade of facilities completed in 1987 took the height of the dam wall from 78 metres (256 ft) to its current height. Glenbawn Dam is operated in conjunction with Glennies Creek Dam . The two dams supply water requirements along 40 kilometres (25 mi) of

517-532: Is a viscoelastic - plastic material that can adjust to the movements and deformations imposed on the embankment as a whole, and to settlement of the foundation. The flexible properties of the asphalt make such dams especially suited to earthquake regions. For the Moglicë Hydro Power Plant in Albania the Norwegian power company Statkraft built an asphalt-core rock-fill dam. Upon completion in 2018

SECTION 10

#1733086042653

564-445: Is a type of fine-grained natural soil material containing clay minerals (hydrous aluminium phyllosilicates, e.g. kaolinite , Al 2 Si 2 O 5 ( OH ) 4 ). Most pure clay minerals are white or light-coloured, but natural clays show a variety of colours from impurities, such as a reddish or brownish colour from small amounts of iron oxide . Clays develop plasticity when wet but can be hardened through firing . Clay

611-620: Is a unique type of marine clay indigenous to the glaciated terrains of Norway , North America , Northern Ireland , and Sweden . It is a highly sensitive clay, prone to liquefaction , and has been involved in several deadly landslides . Modelling clay is used in art and handicraft for sculpting . Clays are used for making pottery , both utilitarian and decorative, and construction products, such as bricks, walls, and floor tiles. Different types of clay, when used with different minerals and firing conditions, are used to produce earthenware, stoneware, and porcelain. Prehistoric humans discovered

658-486: Is at hand, transport is minimized, leading to cost savings during construction. Rock-fill dams are resistant to damage from earthquakes . However, inadequate quality control during construction can lead to poor compaction and sand in the embankment which can lead to liquefaction of the rock-fill during an earthquake. Liquefaction potential can be reduced by keeping susceptible material from being saturated, and by providing adequate compaction during construction. An example of

705-459: Is clay with visible annual layers that are formed by seasonal deposition of those layers and are marked by differences in erosion and organic content. This type of deposit is common in former glacial lakes . When fine sediments are delivered into the calm waters of these glacial lake basins away from the shoreline, they settle to the lake bed. The resulting seasonal layering is preserved in an even distribution of clay sediment banding. Quick clay

752-674: Is important to soil fertility. Clay is a common component of sedimentary rock . Shale is formed largely from clay and is the most common of sedimentary rocks. However, most clay deposits are impure. Many naturally occurring deposits include both silts and clay. Clays are distinguished from other fine-grained soils by differences in size and mineralogy. Silts , which are fine-grained soils that do not include clay minerals, tend to have larger particle sizes than clays. There is, however, some overlap in particle size and other physical properties. The distinction between silt and clay varies by discipline. Geologists and soil scientists usually consider

799-439: Is managed by AGL Energy . The dam is a popular location for water skiing and fishing, both by boat and from shore. Located adjacent to the dam and the lake is a nature reserve ; Lake Glenbawn State Park. Embankment dam Embankment dams come in two types: the earth-filled dam (also called an earthen dam or terrain dam ) made of compacted earth, and the rock-filled dam . A cross-section of an embankment dam shows

846-429: Is the longest-known ceramic material. Prehistoric humans discovered the useful properties of clay and used it for making pottery . Some of the earliest pottery shards have been dated to around 14,000 BCE, and clay tablets were the first known writing medium. Clay is used in many modern industrial processes, such as paper making, cement production, and chemical filtering . Between one-half and two-thirds of

893-512: Is used in many industrial processes, such as paper making, cement production, and chemical filtering . Bentonite clay is widely used as a mold binder in the manufacture of sand castings . Clay is a common filler used in polymer nanocomposites . It can reduce the cost of the composite, as well as impart modified behavior: increased stiffness , decreased permeability , decreased electrical conductivity , etc. Traditional uses of clay as medicine go back to prehistoric times. An example

940-516: The California Gold Rush in the 1860s when miners constructed rock-fill timber-face dams for sluice operations . The timber was later replaced by concrete as the design was applied to irrigation and power schemes. As CFRD designs grew in height during the 1960s, the fill was compacted and the slab's horizontal and vertical joints were replaced with improved vertical joints. In the last few decades, design has become popular. The tallest CFRD in

987-453: The Usoi landslide dam leaks 35-80 cubic meters per second. Sufficiently fast seepage can dislodge a dam's component particles, which results in faster seepage, which turns into a runaway feedback loop that can destroy the dam in a piping-type failure. Seepage monitoring is therefore an essential safety consideration. gn and Construction in the U.S. Bureau of Reclamation Clay Clay

SECTION 20

#1733086042653

1034-539: The 320 m long, 150 m high and 460 m wide dam is anticipated to be the world's highest of its kind. A concrete-face rock-fill dam (CFRD) is a rock-fill dam with concrete slabs on its upstream face. This design provides the concrete slab as an impervious wall to prevent leakage and also a structure without concern for uplift pressure. In addition, the CFRD design is flexible for topography, faster to construct and less costly than earth-fill dams. The CFRD concept originated during

1081-540: The Hunter River from Glenbawn to the tidal reaches near Maitland . The name Glenbawn originates after a riverside property resumed for part of the storage area. A hydro-electric power station generates up to 5.5 megawatts (7,400 hp) of electricity from the flow of the water leaving Glenbawn Dam with an average output of 4.4 gigawatt-hours (16 TJ) per annum. The station was completed in January 1995. The facility

1128-404: The base of the dam than at shallower water levels. Thus the stress level of the dam must be calculated in advance of building to ensure that its break level threshold is not exceeded. Overtopping or overflow of an embankment dam beyond its spillway capacity will cause its eventual failure . The erosion of the dam's material by overtopping runoff will remove masses of material whose weight holds

1175-415: The cohesion that makes it plastic. In kaolinite clay, the bonding between plates is provided by a film of water molecules that hydrogen bond the plates together. The bonds are weak enough to allow the plates to slip past each other when the clay is being moulded, but strong enough to hold the plates in place and allow the moulded clay to retain its shape after it is moulded. When the clay is dried, most of

1222-450: The cost of producing or bringing in concrete would be prohibitive. Rock -fill dams are embankments of compacted free-draining granular earth with an impervious zone. The earth used often contains a high percentage of large particles, hence the term "rock-fill". The impervious zone may be on the upstream face and made of masonry , concrete , plastic membrane, steel sheet piles, timber or other material. The impervious zone may also be inside

1269-434: The dam in place and against the hydraulic forces acting to move the dam. Even a small sustained overtopping flow can remove thousands of tons of overburden soil from the mass of the dam within hours. The removal of this mass unbalances the forces that stabilize the dam against its reservoir as the mass of water still impounded behind the dam presses against the lightened mass of the embankment, made lighter by surface erosion. As

1316-417: The early 21st century. These techniques include concrete overtopping protection systems, timber cribs , sheet-piles , riprap and gabions , Reinforced Earth , minimum energy loss weirs , embankment overflow stepped spillways , and precast concrete block protection systems. All dams are prone to seepage underneath the dam, but embankment dams are prone to seepage through the dam as well; for example,

1363-420: The embankment, in which case it is referred to as a "core". In the instances where clay is used as the impervious material, the dam is referred to as a "composite" dam. To prevent internal erosion of clay into the rock fill due to seepage forces, the core is separated using a filter. Filters are specifically graded soil designed to prevent the migration of fine grain soil particles. When suitable building material

1410-516: The first known writing medium. Clay was chosen due to the local material being easy to work with and widely available. Scribes wrote on the tablets by inscribing them with a script known as cuneiform , using a blunt reed called a stylus , which effectively produced the wedge shaped markings of their writing. After being written on, clay tablets could be reworked into fresh tablets and reused if needed, or fired to make them permanent records. Purpose-made clay balls were used as sling ammunition . Clay

1457-485: The flow of the water and continue to fracture into smaller and smaller sections of earth or rock until they disintegrate into a thick suspension of earth, rocks and water. Therefore, safety requirements for the spillway are high, and require it to be capable of containing a maximum flood stage. It is common for its specifications to be written such that it can contain at least a one-hundred-year flood. A number of embankment dam overtopping protection systems were developed in

Glenbawn Dam - Misplaced Pages Continue

1504-448: The largest earth-filled dam in the world. The principal element of the project is an embankment 9,000 feet (2,700 m) long with a maximum height of 465 feet (142 m). The dam used approximately 200 million cubic yards (152.8 million cu. meters) of fill, which makes it one of the largest man-made structures in the world. Because earthen dams can be constructed from local materials, they can be cost-effective in regions where

1551-423: The mass of the dam erodes, the force exerted by the reservoir begins to move the entire structure. The embankment, having almost no elastic strength, would begin to break into separate pieces, allowing the impounded reservoir water to flow between them, eroding and removing even more material as it passes through. In the final stages of failure, the remaining pieces of the embankment would offer almost no resistance to

1598-404: The material. The clay mineral kaolinite is transformed into a non-clay material, metakaolin , which remains rigid and hard if moistened again. Further firing through the stoneware and porcelain stages further recrystallizes the metakaolin into yet stronger minerals such as mullite . The tiny size and plate form of clay particles gives clay minerals a high surface area. In some clay minerals,

1645-724: The moulded clay is just dry enough to hold its shape. The plastic limit of kaolinite clay ranges from about 36% to 40% and its liquid limit ranges from about 58% to 72%. High-quality clay is also tough, as measured by the amount of mechanical work required to roll a sample of clay flat. Its toughness reflects a high degree of internal cohesion. Clay has a high content of clay minerals that give it its plasticity. Clay minerals are hydrous aluminium phyllosilicate minerals , composed of aluminium and silicon ions bonded into tiny, thin plates by interconnecting oxygen and hydroxide ions. These plates are tough but flexible, and in moist clay, they adhere to each other. The resulting aggregates give clay

1692-467: The plates carry a negative electrical charge that is balanced by a surrounding layer of positive ions ( cations ), such as sodium, potassium, or calcium. If the clay is mixed with a solution containing other cations, these can swap places with the cations in the layer around the clay particles, which gives clays a high capacity for ion exchange . The chemistry of clay minerals, including their capacity to retain nutrient cations such as potassium and ammonium,

1739-476: The rock pieces may need to be crushed into smaller grades to get the right range of size for use in an embankment dam. Earth-fill dams, also called earthen dams, rolled-earth dams or earth dams, are constructed as a simple embankment of well-compacted earth. A homogeneous rolled-earth dam is entirely constructed of one type of material but may contain a drain layer to collect seep water. A zoned-earth dam has distinct parts or zones of dissimilar material, typically

1786-696: The separation to occur at a particle size of 2 μm (clays being finer than silts), sedimentologists often use 4–5 μm, and colloid chemists use 1 μm. Clay-size particles and clay minerals are not the same, despite a degree of overlap in their respective definitions. Geotechnical engineers distinguish between silts and clays based on the plasticity properties of the soil, as measured by the soils' Atterberg limits . ISO 14688 grades clay particles as being smaller than 2 μm and silt particles as being larger. Mixtures of sand , silt and less than 40% clay are called loam . Some clay minerals (such as smectite ) are described as swelling clay minerals, because they have

1833-841: The site of formation. Secondary clays are clays that have been transported from their original location by water erosion and deposited in a new sedimentary deposit. Secondary clay deposits are typically associated with very low energy depositional environments such as large lakes and marine basins. The main groups of clays include kaolinite , montmorillonite - smectite , and illite . Chlorite , vermiculite , talc , and pyrophyllite are sometimes also classified as clay minerals. There are approximately 30 different types of "pure" clays in these categories, but most "natural" clay deposits are mixtures of these different types, along with other weathered minerals. Clay minerals in clays are most easily identified using X-ray diffraction rather than chemical or physical tests. Varve (or varved clay )

1880-748: The town of Scone on the upper reaches of the river. The dam was built by the New South Wales Water Conservation & Irrigation Commission to supply water for irrigation and flood mitigation. The dam wall height is 100 metres (330 ft) and is 1,125 metres (3,691 ft) long. The maximum water depth is 85 metres (279 ft) and at 100% capacity the dam wall holds back 749,840 megalitres (26,480 × 10 ^  cu ft) of water at 276 metres (906 ft) AHD . The dam has an additional reserve capacity of 120,000 megalitres (4,200 × 10 ^  cu ft) to hold floodwaters that reduce flooding downstream. The surface area of Lake Glenbawn

1927-542: The useful properties of clay. Some of the earliest pottery shards recovered are from central Honshu , Japan . They are associated with the Jōmon culture, and recovered deposits have been dated to around 14,000 BCE. Cooking pots, art objects, dishware, smoking pipes , and even musical instruments such as the ocarina can all be shaped from clay before being fired. Ancient peoples in Mesopotamia adopted clay tablets as

Glenbawn Dam - Misplaced Pages Continue

1974-426: The water molecules are removed, and the plates hydrogen bond directly to each other, so that the dried clay is rigid but still fragile. If the clay is moistened again, it will once more become plastic. When the clay is fired to the earthenware stage, a dehydration reaction removes additional water from the clay, causing clay plates to irreversibly adhere to each other via stronger covalent bonding , which strengthens

2021-500: The world is the 233 m-tall (764 ft) Shuibuya Dam in China , completed in 2008. The building of a dam and the filling of the reservoir behind it places a new weight on the floor and sides of a valley. The stress of the water increases linearly with its depth. Water also pushes against the upstream face of the dam, a nonrigid structure that under stress behaves semiplastically, and causes greater need for adjustment (flexibility) near

2068-735: The world's population live or work in buildings made with clay, often baked into brick, as an essential part of its load-bearing structure. Clay is a very common substance. Shale , formed largely from clay, is the most common sedimentary rock. Although many naturally occurring deposits include both silts and clay, clays are distinguished from other fine-grained soils by differences in size and mineralogy. Silts , which are fine-grained soils that do not include clay minerals, tend to have larger particle sizes than clays. Mixtures of sand , silt and less than 40% clay are called loam . Soils high in swelling clays ( expansive clay ), which are clay minerals that readily expand in volume when they absorb water, are

2115-493: The world's population, in both traditional societies as well as developed countries, still live or work in buildings made with clay, often baked into brick, as an essential part of their load-bearing structure. Also a primary ingredient in many natural building techniques, clay is used to create adobe , cob , cordwood , and structures and building elements such as wattle and daub , clay plaster, clay render case, clay floors and clay paints and ceramic building material . Clay

2162-612: Was created through enabling legislation enacted through the passage of the Glenbawn Dam Act, 1946 (NSW). The Act appropriated A£ 1,500,000 as the estimated cost of construction of the dam. Commenced in late 1947 and completed in late 1957, the Glenbawn Dam is a major dam on the Hunter River and is the fourth largest earth-filled embankment dam in Australia by volume. The dam is located approximately 14 kilometres (8.7 mi) east of

2209-461: Was used as a mortar in brick chimneys and stone walls where protected from water. Clay, relatively impermeable to water, is also used where natural seals are needed, such as in pond linings, the cores of dams , or as a barrier in landfills against toxic seepage (lining the landfill, preferably in combination with geotextiles ). Studies in the early 21st century have investigated clay's absorption capacities in various applications, such as

#652347